I'm looking to build a very large custom roof hatch/vent on my van. I was going to make to top out of Lexan, but then I realized I might want a large solar panel on the roof as well. I was looking at the aluminum structure of solar panels and read the edges are water tight. Any reason I can't use the solar panel itself as my hatch top? Structurally I think it will work, and I know panels get hot just like my metal roof gets hot, but wonder if there are any chemical reactions or gases that will enter the van as a result of the back side of the solar panel working. I also know solar panels need ventilation underneath, but then again, so does my van inside during a hot day.
Electrical – Solar panel as a hatch and Is sleeping under a solar panel safe
air-conditioningaluminumelectricalhvacsolar-panels
Related Topic
- Electrical – Looking to setup a 100Amp panel in the attached garage and have ideas/questions
- Electrical – Power Panel Grounding and Neutral Bonding / Dryer hookup in an older home [1975]
- Comparing mixed orientation solar panels to non-mixed on a Brooklyn Solar install
- Calculating daily energy production of PV panels
- DIY Solar Panel Install
- Solar panel setup with battery
- Electrical – How much solar can I get, and when/why would it require digging up the street
Best Answer
No. Solar panels are inert.
Yes. A solar panel has a low albedo, probably much lower than the white roof of your van. So the panel radiates a lot of heat.
Roof hatches on campervans are usually transparent. This has the advantage of bringing natural light into the living space, which makes the cabin feel pleasant and roomy. An opaque hatch only admits light when it's open, and only through the opening, i.e. light falls in from the side, not the top.
If you go camping in colder weather, you'll want insulation under the solar panel, to prevent the panel forming a cold bridge. Campervan roof hatches are double-pane to provide insulation.
One more consideration: if you use a solar panel as a hatch, make sure the panel can withstand the aerodynamic loads.